Total Linhas Aéreas Flight 5561

Total Linhas Aéreas Flight 5561 was a domestic cargo flight from São Paulo, Brazil to Londrina, Brazil that crashed near Paranapanema 47 minutes after takeoff on 14 September 2002. The crew of the ATR 42 regional turboprop lost control of the aircraft's pitch and were both killed in the accident.

The accident was investigated by the Brazilian Air Force's Aeronautical Accidents Investigation and Prevention Center (Centro de Investigação e Prevenção de Acidentes Aeronáuticos (CENIPA)), with a final report issued in March 2007. Investigators concluded that the most likely cause of the accident was a pitch trim control system failure.

Accident

The flight took off from São Paulo at 04:52 local time and at 05:12:30 the crew asked for permission to climb to flight level (FL) 160 i.e. 16,000 feet. At 05:13:18 the co-pilot commented "Damn, it's the wiring harness." The meaning of this statement remains undetermined. At 05:16:03 the aircraft was cleared to climb to FL180 (18000 ft). At 05:29:14 the pilot informed the co-pilot he was going to change his clothes and removed himself from his cockpit seat. At 05:37:32 the "event" button located on the center console was pushed. Five seconds later the autopilot disengaged and the pitch trim control system began moving the trim tabs to a nose down attitude. As the airliner began descending, at 05:37:38 and 05:37:46 the pilot asked the co-pilot what was happening, and he responded that he did not know. Eight seconds later at 05:37:54 the co-pilot exclaimed that the pitch trim control system was running the trim nose down, then the sound of a seat belt buckling was recorded indicating the pilot had returned to his seat. Between 05:37:40 and 05:37:46 one of the crew members attempted to arrest the descent by pulling back on the control column.

At 05:37:55 the pilot told the co-pilot to "Pull the trim" for the first time, meaning pull the circuit breaker (CB) that powers the pitch trim system. This CB is located in a panel behind the co-pilot and is not reachable by the pilot. The co-pilot did not initially understand the pilot's request and the pilot repeated it several times as the pitch trim continued to trim down, eventually reaching and staying at its full down stop of five degrees. At 05:38:05 the co-pilot stated "I pulled, I pulled" and a CB was deactivated.

Flight 5561 was now at 16,000 feet and descending and had accelerated from its cruising speed of 180 to 260 kn. At 05:38:07 the over speed alarm sounded indicating the aircraft had exceeded the maximum operating limit speed (Vmo) and the crew reduced power from the cruise setting to 10%. From 05:38:29 until 05:38:49 the pilot requested of the co-pilot to pull the trim as he continued to pull the control column. The CVR recorded sounds of the aircraft continuing to accelerate, then at 05:39:10 the recording ended. The aircraft collided with the ground in a 30 degrees left bank angle, pitched down approximately 45 degrees at 366 kn. The aircraft was completely destroyed and both crew members perished.