WPR19FA109 · Bell 206 B
Van Horn Aviation Bell 206 B · Accident: mast bumping while maneuvering
From Falcon Field (FFZ) to Falcon Field (FFZ)
Event
- NTSB case
- WPR19FA109
- Event typeAccident: someone killed or seriously injured, or the aircraft substantially damaged (NTSB definition). Incident: an occurrence that affected or could have affected safety, short of that. Glossary
- Accident
- InvestigationHow far the investigation had got when the record was published: preliminary, ongoing, final or completed. Unknown where the source does not say. Glossary
- Completed
- API-reported fatalities
- 2 · all aircraft and ground
- Ground fatalities
- Unknown
- OperationWhat kind of flying it was, grouped by the rules it flew under: airline (US Part 121), air taxi and commuter (Part 135), general aviation (Part 91 and similar), military or government. Glossary
- General aviation
- WeatherVisual meteorological conditions (VMC): good enough to fly by looking outside. Instrument conditions (IMC): cloud or low visibility, flying by instruments. Glossary
- Visual Meteorological Cond
Bell 206 B
- Aircraft type
- Bell 206
- Category
- Helicopter
- RegistrationThe aircraft's tail number, such as N12345 or G-ABCD. Registrations are reissued, so the same one years apart can be a different aircraft. Glossary
- N61PH
- Operator
- Van Horn Aviation
- Onboard fatalities
- Unknown
- Route
- From Falcon Field (FFZ), Mesa, AZTo Falcon Field (FFZ), Mesa, AZ
- Aircraft age
- About 38 years (built 1981)
- Flight rulesThe regulations the flight operated under: in the US, Part 91 (general aviation), Part 121 (airlines), Part 135 (air taxi and commuter) and others; for flights abroad, the NTSB's coarser commercial or non-commercial code. Glossary
- Part 91: General Aviation
- Phase of flightThe stage of the flight when things started to go wrong: standing, taxi, takeoff, initial climb, en route, maneuvering, approach or landing. Glossary
- Maneuvering
- Defining eventThe single coded event the NTSB judges best describes what happened (records from 2008 on). Older records name the first occurrence in the sequence instead. Glossary
- Mast bumping
- DamageDestroyed: beyond practical repair. Substantial: damage that affects the structure, performance or handling and normally needs major repair. Minor: less than that. Glossary
- Destroyed
Cause areas
- Aircraft › Aircraft oper/perf/capability
- Personnel issues › Action/decision
Approximate · Coordinates as recorded by the NTSB; no uncertainty radius is established.
NTSB narrative
The pilot and flight engineer were conducting a flight test to evaluate developmental main rotor blades that had been installed on the helicopter. The flight consisted of multiple autorotations at maximum gross weight, entered following a 1-second delay after a simulated loss of engine power. A witness saw the helicopter falling from the sky and saw several other objects descending to the ground before losing sight of it behind trees.
Examination of the wreckage revealed damage to the main rotor mast, consistent with a mast bumping event. Cyclic controls were installed in both the pilot’s seat and the left seat, where the flight test engineer sat with equipment used for recording flight parameters, including an 8-lb laptop computer. In order for the engineer to operate the computer or take notes on the clipboard, he would have to hold the computer with one hand while using the other to enter commands or take notes. The installation of the cyclic in the engineer’s position represented a deviation from company procedures by both the pilot and the flight test engineer. Examination revealed no evidence of mechanical malfunctions or failures that would have precluded normal operation of the helicopter prior to the mast bumping.
The flight engineer’s fatigue of holding the 8-lb computer over his lap, the awkwardness of entering commands with one hand, or taking notes single-handedly may have allowed the computer to suddenly shift and strike or block the cyclic during the simulated loss of power test at the critical low-G flight condition.
Probable cause
The separation of the main rotor head from the mast as a result of a sudden displacement of the cyclic stick during a low-G maneuver, leading to mast bumping. Contributing to the accident were the unsecure positioning of the flight test engineer’s laptop computer and the deviation from standard operating procedures to leave the left seat cyclic control installed during the test flight.
Verbatim NTSB analysis and probable cause from the NTSB dataset
Sources
NTSB record WPR19FA109
- Event ID
- 20190416X22532
- Case number
- WPR19FA109
- Dataset
- full-current
- Source SHA-256
- 5cf380f0061817c0331a6b2d8cc7e0ee3a79bea469a1001dc5c10e56f35f5ab3
Source notes (4)
- Unreviewed is an editorial label, not an investigation status. API-sourced is not report-checked or human-reviewed. Explicit event totals are used without summing aircraft injury tables; onboard allocation is withheld. Unknown values remain unknown. The operation category is mapped from the NTSB-reported FAR part and has not been reviewed.
- Filled from the NTSB case API where the bulk record had no value: investigation status, cause areas. Values present in the bulk record are kept.
- The date is the local date, which is the same as the UTC date the NTSB stores.
- API snapshot SHA-256: 412479b9680656da5ce37bbfc2cdd6f9bfbfdd2c445554c86b509d6eb16dd65f; retrieved 2026-09-15T06:56:36.192Z.