CEN15LA018 · Viguie G/Viguie M LANCAIR LEGACY
Viguie G/Viguie M LANCAIR LEGACY · Accident: loss of engine power (total) en route
From Jasper County Airport Bell Field (JAS) to Buchanan Dam, TX
Event
- NTSB case
- CEN15LA018
- Event typeAccident: someone killed or seriously injured, or the aircraft substantially damaged (NTSB definition). Incident: an occurrence that affected or could have affected safety, short of that. Glossary
- Accident
- InvestigationHow far the investigation had got when the record was published: preliminary, ongoing, final or completed. Unknown where the source does not say. Glossary
- Completed
- API-reported fatalities
- 0 · all aircraft and ground
- Ground fatalities
- Unknown
- OperationWhat kind of flying it was, grouped by the rules it flew under: airline (US Part 121), air taxi and commuter (Part 135), general aviation (Part 91 and similar), military or government. Glossary
- General aviation
- WeatherVisual meteorological conditions (VMC): good enough to fly by looking outside. Instrument conditions (IMC): cloud or low visibility, flying by instruments. Glossary
- Visual Meteorological Cond
Viguie G/Viguie M LANCAIR LEGACY
- Aircraft type
- Viguie G/viguie LANCAIR LEGACY
- Category
- Airplane
- RegistrationThe aircraft's tail number, such as N12345 or G-ABCD. Registrations are reissued, so the same one years apart can be a different aircraft. Glossary
- N550AC
- Operator
- Crawford Alan R
- Onboard fatalities
- Unknown
- Route
- From Jasper County Airport Bell Field (JAS), Jasper, TXTo Buchanan Dam, TX
- Aircraft age
- About 6 years (built 2008)
- Flight rulesThe regulations the flight operated under: in the US, Part 91 (general aviation), Part 121 (airlines), Part 135 (air taxi and commuter) and others; for flights abroad, the NTSB's coarser commercial or non-commercial code. Glossary
- Part 91: General Aviation
- Phase of flightThe stage of the flight when things started to go wrong: standing, taxi, takeoff, initial climb, en route, maneuvering, approach or landing. Glossary
- En route
- Defining eventThe single coded event the NTSB judges best describes what happened (records from 2008 on). Older records name the first occurrence in the sequence instead. Glossary
- Loss of engine power (total)
- DamageDestroyed: beyond practical repair. Substantial: damage that affects the structure, performance or handling and normally needs major repair. Minor: less than that. Glossary
- Destroyed
Cause areas
- Aircraft › Aircraft power plant
- Aircraft › Fluids/miscellaneous hardware
Approximate · Coordinates as recorded by the NTSB; no uncertainty radius is established.
NTSB narrative
The pilot reported that he was returning from an air race competition and that, about 15 minutes into the flight, he heard a "thump" and thought the airplane had struck a bird. The pilot then heard a second "thump" along with a "rattle and vibration," so he found a place to make a forced landing. While preparing to land, he heard an "explosion" and then saw flames by his left foot and black smoke fill the cockpit. The pilot made a forced landing to a field and exited the airplane before it was destroyed by fire.
Postaccident examination of the engine revealed that the No. 3 cylinder's exhaust rocker cover was present but that it was only installed on the cylinder by one screw. The other four screws were missing. The No. 3 cylinder's intake rocker cover and aft rocker arm bolt were missing. The forward rocker arm bolt was installed but loose, and visible rubbing was observed on the boss where the missing bolt was supposed to be installed. According to the engine manufacturer, if a rocker cover is not installed, the engine will port out most of its oil is several minutes. Therefore, the missing rocker cover likely resulted in the engine losing a significant amount of oil during the flight, which led to a catastrophic and uncontained engine failure. It is also likely that, when the crankcase was breached, the fuel lines and the electronic fuel transducer were compromised, which resulted in the subsequent in-flight fire. The No. 3 cylinder intake rocker cover was not located at the accident site, and the pilot reported that he did not know why the rocker cover and aft rocker arm bolt were not installed or why the exhaust rocker cover was only partially installed. He said that the engine performed great during the air race and that he did not perform engine maintenance after the race.
Probable cause
A catastrophic and uncontained engine failure due to oil starvation. Contributing to the accident was the missing No. 3 cylinder intake rocker cover for reasons that could not be determined based on the available evidence.
Verbatim NTSB analysis and probable cause from the NTSB dataset
Sources
NTSB record CEN15LA018
- Event ID
- 20141020X51031
- Case number
- CEN15LA018
- Dataset
- full-current
- Source SHA-256
- 5cf380f0061817c0331a6b2d8cc7e0ee3a79bea469a1001dc5c10e56f35f5ab3
Source notes (4)
- Unreviewed is an editorial label, not an investigation status. API-sourced is not report-checked or human-reviewed. Explicit event totals are used without summing aircraft injury tables; onboard allocation is withheld. Unknown values remain unknown. The operation category is mapped from the NTSB-reported FAR part and has not been reviewed.
- Filled from the NTSB case API where the bulk record had no value: investigation status. Values present in the bulk record are kept.
- The date is the local date, which is the same as the UTC date the NTSB stores.
- API snapshot SHA-256: cb8bea3f770f7b716fac63bd5c42d1d51a2647dc481e2fe5d6b6699bf7c07b50; retrieved 2026-09-16T01:52:07.930Z.