LAX05GA231 · Eurocopter France EC120B
Eurocopter France EC120B · Accident: total loss of engine power (mechanical failure) while maneuvering
From Sacramento Mather Airport (KMHR) to an unrecorded destination
Event
- NTSB case
- LAX05GA231
- Event typeAccident: someone killed or seriously injured, or the aircraft substantially damaged (NTSB definition). Incident: an occurrence that affected or could have affected safety, short of that. Glossary
- Accident
- InvestigationHow far the investigation had got when the record was published: preliminary, ongoing, final or completed. Unknown where the source does not say. Glossary
- Completed
- API-reported fatalities
- 2 · all aircraft and ground
- Ground fatalities
- Unknown
- OperationWhat kind of flying it was, grouped by the rules it flew under: airline (US Part 121), air taxi and commuter (Part 135), general aviation (Part 91 and similar), military or government. Glossary
- Government
- WeatherVisual meteorological conditions (VMC): good enough to fly by looking outside. Instrument conditions (IMC): cloud or low visibility, flying by instruments. Glossary
- Visual Meteorological Cond
Eurocopter France EC120B
- Aircraft type
- Eurocopter EC120
- Category
- Helicopter
- RegistrationThe aircraft's tail number, such as N12345 or G-ABCD. Registrations are reissued, so the same one years apart can be a different aircraft. Glossary
- N266SD
- Operator
- Unknown
- Onboard fatalities
- Unknown
- Route
- From Sacramento Mather Airport (KMHR), Mather, CATo not recorded
- Aircraft age
- Not recorded
- Flight rulesThe regulations the flight operated under: in the US, Part 91 (general aviation), Part 121 (airlines), Part 135 (air taxi and commuter) and others; for flights abroad, the NTSB's coarser commercial or non-commercial code. Glossary
- Public Aircraft
- Phase of flightThe stage of the flight when things started to go wrong: standing, taxi, takeoff, initial climb, en route, maneuvering, approach or landing. Glossary
- Maneuvering
- First occurrenceThe single coded event the NTSB judges best describes what happened (records from 2008 on). Older records name the first occurrence in the sequence instead. Glossary
- Total loss of engine power (mechanical failure)
- DamageDestroyed: beyond practical repair. Substantial: damage that affects the structure, performance or handling and normally needs major repair. Minor: less than that. Glossary
- Destroyed
Cause areas
- Fluid, fuel › Excessive flow/output
- Fuel system, fuel control › Failure, total
- Manufacturer › Maintenance, installation, reversed
Approximate · Coordinates from the NTSB case API, which marks them as estimated or does not say; no uncertainty radius is established.
NTSB narrative
The engine experienced an overspeed and catastrophic failure on a law enforcement patrol flight and the helicopter collided with hilly terrain during a subsequent autorotation attempt. Witnesses reported the helicopter began emitting smoke and subsequently descended, impacting terrain near the bottom of a 60-degree sloped hillside. The terrain around the accident site was either steeply sloped hillside with mature trees or bordered by power lines. A post accident examination of the engine and components revealed the constant delta P diaphragm (located in the fuel control unit) had ruptured, resulting in a high and uncontrolled increase of fuel flow to the engine. The power turbine exhibited evidence of a substantial overspeed. All of the turbine blades were separated at their respective shear points. The gas generator turbine exhibited evidence of extreme thermal erosion; the blades were eroded to about 50 percent of their normal height. The centrifugal compressor exhibited evidence of extreme rubbing. A detailed examination of the diaphragm revealed that it had been installed incorrectly (inside-out). The maintenance and engine manufacturer's build records revealed that the diaphragm was last replaced at the engine manufacturer's facilities in France. Recovered Vehicle and Engine Multifunctional Display (VEMD) information supported the evidence of an engine and main rotor revolutions per minute (rpm) exceedance.
Probable cause
The failure of the constant delta P diaphragm in the fuel control unit, which resulted in an increased fuel flow and subsequent catastrophic failure of the engine. The diaphragm's failure was the result of improper installation by the engine manufacturer. A factor in the accident was the unsuitable nature of the terrain for a successful autorotation.
Verbatim NTSB analysis and probable cause from the NTSB dataset
Sources
NTSB record LAX05GA231
- Event ID
- 20050718X01046
- Case number
- LAX05GA231
- Dataset
- historical-pre2008
- Source SHA-256
- 89e2df6d848e7ab3b42e7d7c7a03ff403303057a26ca04c95b3ea67201c3ce74
Source notes (4)
- Unreviewed is an editorial label, not an investigation status. API-sourced is not report-checked or human-reviewed. Explicit event totals are used without summing aircraft injury tables; onboard allocation is withheld. Unknown values remain unknown. The operation category is mapped from the NTSB-reported FAR part and has not been reviewed.
- Filled from the NTSB case API where the bulk record had no value: local date, investigation status, coordinates. Values present in the bulk record are kept.
- The date is the local date; the NTSB stores the UTC date 2005-07-14.
- API snapshot SHA-256: f92bcd8b4ec6524adf236027d3e9ee68c2113191d70ac7e6b3806e8d7debf39f; retrieved 2026-09-18T14:34:23.979Z.