American Airlines Flight 1420

American Airlines Flight 1420 was a scheduled domestic passenger flight from Dallas Fort Worth International Airport (DFW) to Little Rock National Airport in the United States. On Tuesday, June 1st, 1999, the McDonnell Douglas MD-82 operating as Flight 1420 overran the runway upon landing in Little Rock and crashed. 9 of the 145 people aboard were immediately killed—the captain and eight passengers—and 2 more passengers died in the hospital in the following weeks.

Flight crew

Flight 1420 was commanded by Captain Richard Buschmann, age 48, an experienced pilot with 10,234 flight hours, nearly half of which were accumulated flying the MD-80 series of aircraft. Buschmann graduated from the United States Air Force Academy in 1972, and served in the Air Force until 1979. He held the rank of lieutenant colonel with the US Air Force Reserve Command, and was hired by American Airlines in July 1979. Experienced at flying the Boeing 727 for American, he transitioned to flying the twin-engine MD-80 series in 1991.

The flight's first officer was Michael Origel, age 35. The first officer had been with the airline for less than a year, and had only 182 hours of flight time with American Airlines as an MD-80 pilot. However, the first officer had trained as a pilot with the United States Navy, and had prior commercial flight experience as a corporate pilot, with a total of 4,292 hours of experience at the time of the incident.

Flight 1420 was staffed with four flight attendants, all of whom were qualified on the MD-80, and had recently received refresher training on emergency procedures.

Flight and weather conditions

Flight 1420 was scheduled to depart DFW at 20:28 (8:28 pm) Central Daylight Time, and then arrive in Little Rock at 21:41 (9:41 pm). The pilots were advised before they boarded that the departure would be delayed, and that the National Weather Service had issued in-flight weather advisories indicating severe thunderstorms along their planned flight path. Adverse weather caused the plane that was intended for Flight 1420 to be delayed in arriving at DFW. Airline policy set a maximum pilot duty time of 14 hours, and Flight 1420 was the flight crew's last flight of the day. The first officer notified the airline's flight dispatcher that the flight crew would, therefore, be unable to depart after 23:16 (11:16 pm). The airline substituted another MD-80, tail number N215AA, which allowed Flight 1420 to depart DFW at 22:40 (10:40 pm).

At 23:04 (11:04 pm), air traffic controllers issued a weather advisory indicating severe thunderstorms in an area that included the Little Rock airport, and the flight crew witnessed lightning while on approach. The flight crew discussed the weather reports, but decided to expedite the approach rather than diverting to the designated alternate airport (Nashville International Airport) or returning to DFW.

Air traffic control at Little Rock had originally told Flight 1420 to expect an approach to Runway 22L. At 23:39 (11:39 pm), a controller advised the crew of a wind-shear alert and a change in wind direction. As a result, Captain Buschmann requested a change to Runway 4R, so the flight would have a headwind during landing, and Flight 1420 was cleared for a visual approach to this runway. Because the plane was already close to the airport, the controller had to direct it away to line it up for a landing on 4R. As a result, Flight 1420 faced away from the airport for several minutes, and due to the plane's weather radar capabilities being limited to a narrow and forward-facing field of view, the flight crew could not see thunderstorms approaching the airport during their turn. As the aircraft approached, a severe thunderstorm arrived over the airport, and at 23:44 (11:44 pm), the first officer notified the controller that the crew had lost sight of the runway. The controller then cleared the aircraft to land on 4R using an instrument landing system (ILS) approach.

The pilots rushed to land as soon as possible, leading to errors in judgment that included the crew's failure to complete the MD-82's pre-landing checklist before descending. This was a crucial event in the accident chain, as the crew overlooked multiple critical landing systems on the checklist. The flight crew failed to arm the automatic spoiler system, which automatically moves the spoiler control lever, and deploys the spoilers upon landing. The pilots also failed to set the plane's automatic braking system. Furthermore, the pilots failed to set the landing flaps, another item on the before landing checklist, but as the plane descended past 1000 feet, the first officer realized the flaps were not set, and the flight crew set the flaps at 40° setting for landing.

At 23:49:32 (11:49:32 pm), the controller issued the last weather report before Flight 1420's landing, and advised that winds at the airport were 330° at 25 kn. The reported winds exceeded the MD-82's 20 kn crosswind limit for landing in reduced visibility on a wet runway. Despite the excessive crosswind and two wind-shear reports, Captain Buschmann did not abandon the aircraft's approach into Little Rock, deciding to continue the approach to 4R instead.

Accident

The aircraft touched down on Runway 4R at 23:50:20 (11:50:20 pm). About two seconds after the wheels touched down, First Officer Origel stated, "We're down. We're sliding!" Because the pilots failed to arm the automatic spoiler, the spoilers did not deploy automatically on landing, and neither pilot deployed them manually.

Autospoilers and autobrakes immediately activate their associated systems as soon as the plane touches down, improving the plane's ability to stop within the confines of a wet runway, especially one that is being subjected to strong and gusting winds, although both can be activated manually by the pilots if they choose to do so. Spoilers disrupt the airflow over the wings, prevent them from generating lift, and cause more of the plane's weight to be borne by the landing gear. About 65% of Flight 1420's weight would have been supported by the plane's landing gear if the spoilers had been deployed, but without the spoilers, this number dropped to only 15%, meaning that AA 1420 had no chance to stop on the runway.

With the light loading of the landing gear, the aircraft's brakes were ineffective at slowing down the plane, which continued down the runway at high speed. Directional control was lost when Captain Buschmann applied too much reverse thrust, which reduced the effectiveness of the plane's rudder and vertical stabilizer.

The aircraft continued past the end of the runway, overrunning and traveling another 800 ft, before striking a security fence and an ILS localizer array. The aircraft then collided with a structure built to support the approach lights for Runway 22L, which extended out into the Arkansas River.

Such structures are usually frangible, designed to shear off on impact, but because the approach lights were located on the unstable riverbank, they were firmly anchored. The collision with the sturdy structure crushed the airplane's nose, and destroyed the left side of the plane's fuselage from the cockpit back to the first two rows of coach seating, killing Captain Buschmann instantly. The impact broke the aircraft apart into large sections, which came to a rest short of the riverbank.

Captain Buschmann and eight of the plane's 139 passengers were immediately killed in the crash. Another two passengers died in the hospital in the weeks that followed. First Officer Origel, three of the four flight attendants, and 41 passengers sustained serious injuries, the remaining flight attendant and 64 passengers sustained minor injuries, and 24 passengers sustained no injuries.