CEN25LA309 · Vans RV4
Vans RV4 · Accident: electrical system malfunction/failure en route
From Dupage Airport (DPA) to Landings Condominium Airport (82IS)
Narrative check · The NTSB narrative appears to contradict this record's departure or destination. Values are shown as recorded, not corrected; compare with the narrative.
Event
- NTSB case
- CEN25LA309
- Event typeAccident: someone killed or seriously injured, or the aircraft substantially damaged (NTSB definition). Incident: an occurrence that affected or could have affected safety, short of that. Glossary
- Accident
- InvestigationHow far the investigation had got when the record was published: preliminary, ongoing, final or completed. Unknown where the source does not say. Glossary
- Ongoing
- Event fatalities
- Unknown
- Ground fatalities
- Unknown
- OperationWhat kind of flying it was, grouped by the rules it flew under: airline (US Part 121), air taxi and commuter (Part 135), general aviation (Part 91 and similar), military or government. Glossary
- General aviation
- WeatherVisual meteorological conditions (VMC): good enough to fly by looking outside. Instrument conditions (IMC): cloud or low visibility, flying by instruments. Glossary
- Visual Meteorological Cond
Vans RV4
- Aircraft type
- Vans RV4
- Category
- Airplane
- RegistrationThe aircraft's tail number, such as N12345 or G-ABCD. Registrations are reissued, so the same one years apart can be a different aircraft. Glossary
- N595BS
- Operator
- Unknown
- Onboard fatalities
- Unknown
- Route Possible conflict
- From Dupage Airport (DPA), Dupage, ILTo Landings Condominium Airport (82IS), Huntley, IL
- Aircraft age
- About 24 years (built 2001)
- Flight rulesThe regulations the flight operated under: in the US, Part 91 (general aviation), Part 121 (airlines), Part 135 (air taxi and commuter) and others; for flights abroad, the NTSB's coarser commercial or non-commercial code. Glossary
- Part 91: General Aviation
- Phase of flightThe stage of the flight when things started to go wrong: standing, taxi, takeoff, initial climb, en route, maneuvering, approach or landing. Glossary
- En route
- Defining eventThe single coded event the NTSB judges best describes what happened (records from 2008 on). Older records name the first occurrence in the sequence instead. Glossary
- Electrical system malfunction/failure
- DamageDestroyed: beyond practical repair. Substantial: damage that affects the structure, performance or handling and normally needs major repair. Minor: less than that. Glossary
- Substantial
Cause areas
No findings designated as a cause are recorded in the NTSB data yet.
Approximate · Coordinates from the NTSB case API, which marks them as estimated or does not say; no uncertainty radius is established.
NTSB narrative
On August 6, 2025, about 1925 central daylight time, a Vans RV4 airplane, N595BS, was substantially damaged when it was involved in an accident near Elgin, Illinois. The pilot and passenger were not injured. The airplane was operated as a Title 14 Code of Federal Regulations Part 91 as a personal flight. The pilot reported that during cruise flight at 1,000 ft above ground level, he noticed an increase in electrical voltage. He turned the airplane toward the departure airport and noted the voltage indicated 20 volts before the entire instrument panel lost power, and then the engine lost power. He also noticed a small smoke plume from behind the instrument panel. The pilot made a forced landing to a golf course during which the airplane sustained substantial damage to the fuselage and engine mount. The engine was equipped with two E-Mag electronic ignition systems. Both magnetos were retained for further examination. Devices capable of recording data were sent to the NTSB Vehicle Recorders Laboratory for further analysis. The airplane was retained for further examination.
Verbatim NTSB factual narrative from the NTSB dataset
Sources
NTSB record CEN25LA309
- Event ID
- 20250807200735
- Case number
- CEN25LA309
- Dataset
- full-current
- Source SHA-256
- 5cf380f0061817c0331a6b2d8cc7e0ee3a79bea469a1001dc5c10e56f35f5ab3
Source notes (4)
- Unreviewed is an editorial label, not an investigation status. API-sourced is not report-checked or human-reviewed. Explicit event totals are used without summing aircraft injury tables; onboard allocation is withheld. Unknown values remain unknown. The operation category is mapped from the NTSB-reported FAR part and has not been reviewed.
- Filled from the NTSB case API where the bulk record had no value: local date, investigation status, coordinates. Values present in the bulk record are kept.
- The date is the local date; the NTSB stores the UTC date 2025-08-07.
- API snapshot SHA-256: 12f7491f4cef7244dc5027782ce802e5663856a1f9d941ce318c9419055d11ab; retrieved 2026-09-16T20:11:25.230Z.