ERA20LA309 · Piper PA28 181
Lebanon Flying Club Piper PA28 181 · Accident: loss of control in flight during an emergency descent
From Warren County Memorial Airport (RNC) to Warren County Memorial Airport (RNC)
Event
- NTSB case
- ERA20LA309
- Event typeAccident: someone killed or seriously injured, or the aircraft substantially damaged (NTSB definition). Incident: an occurrence that affected or could have affected safety, short of that. Glossary
- Accident
- InvestigationHow far the investigation had got when the record was published: preliminary, ongoing, final or completed. Unknown where the source does not say. Glossary
- Completed
- API-reported fatalities
- 3 · all aircraft and ground
- Ground fatalities
- 0
- OperationWhat kind of flying it was, grouped by the rules it flew under: airline (US Part 121), air taxi and commuter (Part 135), general aviation (Part 91 and similar), military or government. Glossary
- General aviation
- WeatherVisual meteorological conditions (VMC): good enough to fly by looking outside. Instrument conditions (IMC): cloud or low visibility, flying by instruments. Glossary
- Visual Meteorological Cond
Piper PA28 181
- Aircraft type
- Piper PA28
- Category
- Airplane
- RegistrationThe aircraft's tail number, such as N12345 or G-ABCD. Registrations are reissued, so the same one years apart can be a different aircraft. Glossary
- N4166Z
- Operator
- Lebanon Flying Club
- Onboard fatalities
- Unknown
- Route
- From Warren County Memorial Airport (RNC), McMinnville, TNTo Warren County Memorial Airport (RNC), McMinnville, TN
- Aircraft age
- About 20 years (built 2000)
- Flight rulesThe regulations the flight operated under: in the US, Part 91 (general aviation), Part 121 (airlines), Part 135 (air taxi and commuter) and others; for flights abroad, the NTSB's coarser commercial or non-commercial code. Glossary
- Part 91: General Aviation
- Phase of flightThe stage of the flight when things started to go wrong: standing, taxi, takeoff, initial climb, en route, maneuvering, approach or landing. Glossary
- Emergency descent
- Defining eventThe single coded event the NTSB judges best describes what happened (records from 2008 on). Older records name the first occurrence in the sequence instead. Glossary
- Loss of control in flight
- DamageDestroyed: beyond practical repair. Substantial: damage that affects the structure, performance or handling and normally needs major repair. Minor: less than that. Glossary
- Substantial
Cause areas
- Aircraft › Aircraft oper/perf/capability
- Aircraft › Aircraft power plant
- Personnel issues › Task performance
Approximate · Coordinates as recorded by the NTSB; no uncertainty radius is established.
NTSB narrative
During initial climb, below 500 ft above ground level, the engine experienced a total loss of power due to a separated cylinder head. The pilot initiated a right turn (based on the orientation of the wreckage) and the airplane stalled and spun flat into a field. Metallurgical examination of the cylinder revealed fatigue cracking, which was observed around approximately 180° of the cylinder circumference. The fatigue cracking emanated from the vertical stiffener on the front of the cylinder between the third and fourth fins. The fatigue cracking appeared to initiate at the start of the fillet between the vertical stiffener and the circumferential outer wall of the cylinder. The remainder of the fracture surface was consistent with overstress. The cylinder was installed new when the engine was overhauled about 19 months prior to the accident. The engine had accrued about 671 hours since overhaul.
Probable cause
A total loss of engine power due to a fatigue failure in a cylinder, and the pilot’s subsequent failure to maintain airspeed and her exceedance of the airplane’s critical angle-of-attack while maneuvering at low altitude.
Verbatim NTSB analysis and probable cause from the NTSB dataset
Sources
NTSB record ERA20LA309
- Event ID
- 20200908X33742
- Case number
- ERA20LA309
- Dataset
- full-current
- Source SHA-256
- 5cf380f0061817c0331a6b2d8cc7e0ee3a79bea469a1001dc5c10e56f35f5ab3
Source notes (4)
- Unreviewed is an editorial label, not an investigation status. API-sourced is not report-checked or human-reviewed. Explicit event totals are used without summing aircraft injury tables; onboard allocation is withheld. Unknown values remain unknown. The operation category is mapped from the NTSB-reported FAR part and has not been reviewed.
- Filled from the NTSB case API where the bulk record had no value: investigation status, cause areas. Values present in the bulk record are kept.
- The date is the local date, which is the same as the UTC date the NTSB stores.
- API snapshot SHA-256: d30970069f117043cc953ce06cf16012401bd40508a162aac5ddc085716fd0f4; retrieved 2026-09-15T07:19:30.424Z.