ERA18FA138 · Piper PA32 300
Piper PA32 300 · Accident: fire/smoke (non-impact) during takeoff
From Greenwood Lake Airport (4N1) to Orange County Airport (MGJ)
Event
- NTSB case
- ERA18FA138
- Event typeAccident: someone killed or seriously injured, or the aircraft substantially damaged (NTSB definition). Incident: an occurrence that affected or could have affected safety, short of that. Glossary
- Accident
- InvestigationHow far the investigation had got when the record was published: preliminary, ongoing, final or completed. Unknown where the source does not say. Glossary
- Completed
- API-reported fatalities
- 1 · all aircraft and ground
- Ground fatalities
- Unknown
- OperationWhat kind of flying it was, grouped by the rules it flew under: airline (US Part 121), air taxi and commuter (Part 135), general aviation (Part 91 and similar), military or government. Glossary
- General aviation
- WeatherVisual meteorological conditions (VMC): good enough to fly by looking outside. Instrument conditions (IMC): cloud or low visibility, flying by instruments. Glossary
- Visual Meteorological Cond
Piper PA32 300
- Aircraft type
- Piper PA32
- Category
- Airplane
- RegistrationThe aircraft's tail number, such as N12345 or G-ABCD. Registrations are reissued, so the same one years apart can be a different aircraft. Glossary
- N4153R
- Operator
- Unknown
- Onboard fatalities
- Unknown
- Route
- From Greenwood Lake Airport (4N1), West Milford, NJTo Orange County Airport (MGJ), Montgomery, NY
- Aircraft age
- About 50 years (built 1968)
- Flight rulesThe regulations the flight operated under: in the US, Part 91 (general aviation), Part 121 (airlines), Part 135 (air taxi and commuter) and others; for flights abroad, the NTSB's coarser commercial or non-commercial code. Glossary
- Part 91: General Aviation
- Phase of flightThe stage of the flight when things started to go wrong: standing, taxi, takeoff, initial climb, en route, maneuvering, approach or landing. Glossary
- Takeoff
- Defining eventThe single coded event the NTSB judges best describes what happened (records from 2008 on). Older records name the first occurrence in the sequence instead. Glossary
- Fire/smoke (non-impact)
- DamageDestroyed: beyond practical repair. Substantial: damage that affects the structure, performance or handling and normally needs major repair. Minor: less than that. Glossary
- Destroyed
Cause areas
- Aircraft › Fluids/miscellaneous hardware
Approximate · Coordinates from the NTSB case API, which marks them as estimated or does not say; no uncertainty radius is established.
NTSB narrative
The private pilot told a friend that he was having problems with his airplane's engine and stated that he was going to taxi to the end of the runway and perform an engine run-up. If the engine run-up was successful, the pilot was going to conduct a short cross-country flight and return. During takeoff, the engine experienced a total loss of power; the airplane subsequently impacted a wooded area about 1,100 ft south of the departure runway.
Examination of the wreckage revealed that the airplane experienced an in-flight fire, with the heaviest concentration of thermal damage on the aft right side of the engine compartment. The fuel inlet line from the fuel pump to the fuel servo was loose. According to the manufacturer, the part number of the inlet line installed on the accident airplane was not approved for aircraft use; however, aside from the part number, the approved hose looked identical to the unapproved hose, and the error likely could not be detected during an annual inspection. The airplane's maintenance logbooks were destroyed during the accident and the pilot performed some of the maintenance of the airplane himself; therefore, when and by whom the unapproved hose was installed could not be determined. It is likely that the loose fuel line allowed fuel to spray onto the exhaust system, which resulted in the in-flight fire and the total loss of engine power.
Probable cause
An in-flight fire and total loss of engine power after takeoff due to a loose fuel line. Contributing to the accident was the installation of an unapproved fuel line by unknown personnel.
Verbatim NTSB analysis and probable cause from the NTSB dataset
Sources
NTSB record ERA18FA138
- Event ID
- 20180502X52741
- Case number
- ERA18FA138
- Dataset
- full-current
- Source SHA-256
- 5cf380f0061817c0331a6b2d8cc7e0ee3a79bea469a1001dc5c10e56f35f5ab3
Source notes (4)
- Unreviewed is an editorial label, not an investigation status. API-sourced is not report-checked or human-reviewed. Explicit event totals are used without summing aircraft injury tables; onboard allocation is withheld. Unknown values remain unknown. The operation category is mapped from the NTSB-reported FAR part and has not been reviewed.
- Filled from the NTSB case API where the bulk record had no value: investigation status, coordinates. Values present in the bulk record are kept.
- The date is the local date, which is the same as the UTC date the NTSB stores.
- API snapshot SHA-256: 998cdb9a11f6fe51a6ffdc96037979f93276d14c408ca90a8b67a4c686148602; retrieved 2026-09-15T06:39:59.207Z.