WPR17LA164 · Piper PA 28R-180
Piper PA 28R-180 · Accident: loss of control in flight during takeoff
From Reid-Hillview Airport of Santa Clara County (RHV) to Marina, CA
Event
- NTSB case
- WPR17LA164
- Event typeAccident: someone killed or seriously injured, or the aircraft substantially damaged (NTSB definition). Incident: an occurrence that affected or could have affected safety, short of that. Glossary
- Accident
- InvestigationHow far the investigation had got when the record was published: preliminary, ongoing, final or completed. Unknown where the source does not say. Glossary
- Completed
- API-reported fatalities
- 0 · all aircraft and ground
- Ground fatalities
- Unknown
- OperationWhat kind of flying it was, grouped by the rules it flew under: airline (US Part 121), air taxi and commuter (Part 135), general aviation (Part 91 and similar), military or government. Glossary
- General aviation
- WeatherVisual meteorological conditions (VMC): good enough to fly by looking outside. Instrument conditions (IMC): cloud or low visibility, flying by instruments. Glossary
- Visual Meteorological Cond
Piper PA 28R-180
- Aircraft type
- Piper PA-28
- Category
- Airplane
- RegistrationThe aircraft's tail number, such as N12345 or G-ABCD. Registrations are reissued, so the same one years apart can be a different aircraft. Glossary
- N4594J
- Operator
- Unknown
- Onboard fatalities
- Unknown
- Route
- From Reid-Hillview Airport of Santa Clara County (RHV), San Jose, CATo Marina, CA
- Aircraft age
- About 49 years (built 1968)
- Flight rulesThe regulations the flight operated under: in the US, Part 91 (general aviation), Part 121 (airlines), Part 135 (air taxi and commuter) and others; for flights abroad, the NTSB's coarser commercial or non-commercial code. Glossary
- Part 91: General Aviation
- Phase of flightThe stage of the flight when things started to go wrong: standing, taxi, takeoff, initial climb, en route, maneuvering, approach or landing. Glossary
- Takeoff
- Defining eventThe single coded event the NTSB judges best describes what happened (records from 2008 on). Older records name the first occurrence in the sequence instead. Glossary
- Loss of control in flight
- DamageDestroyed: beyond practical repair. Substantial: damage that affects the structure, performance or handling and normally needs major repair. Minor: less than that. Glossary
- Substantial
Cause areas
- Aircraft › Aircraft systems
- Personnel issues › Task performance
Approximate · Coordinates as recorded by the NTSB; no uncertainty radius is established.
NTSB narrative
The commercial pilot reported that the accident flight was the first flight following maintenance, which included the installation of right-seat rudder pedals with brake controls. The pilot stated that, during a preflight inspection of the airplane, he actuated the ailerons; however, he did not verify which direction the control yoke moved. He again checked the flight control movement before takeoff but did not verify which direction the aileron moved when he moved the control yoke. During the takeoff sequence, as the airplane became airborne, it immediately entered an uncommanded left roll. The pilot attempted to correct for the roll; however, he was unable to do so and subsequently reduced the engine power. The airplane then impacted the ground and came to rest upright on an adjacent runway.
Postaccident examination of the airplane revealed that, when the control yoke was rotated for input of right aileron, the right aileron moved down, and the left aileron moved up, which is opposite of what would be expected. Examination of the aileron cables revealed that they remained attached to the "T" bar aileron control chains; however, the right aileron control cable was attached to the left aileron control chain, and the left aileron control cable was attached to the right aileron control chain; thus, the cables were connected backward.
The cables were oriented such that they crossed underneath the flap handle and center console area. The two mechanics who performed the maintenance on the airplane reported that they had disconnected the aileron control cables to facilitate the installation of the rudder pedals and brake controls. After completing the maintenance, they checked the flight control cable tension and aileron movement; however, they did not observe which direction the control yoke moved when the aileron was moved. It is likely that the mechanics attached the aileron control cables backward during the reassembly of the aileron control system, which resulted in roll control that was opposite of that commanded by the pilot.
Probable cause
Maintenance personnel's incorrect installation of the aileron control cables and subsequent failure to verify proper aileron functionality following the maintenance, which resulted in roll control that was opposite of that commanded by the pilot, and the pilot's inadequate preflight inspection, during which he did not verify that the aileron movement matched the control yoke input.
Verbatim NTSB analysis and probable cause from the NTSB dataset
Sources
NTSB record WPR17LA164
- Event ID
- 20170724X10817
- Case number
- WPR17LA164
- Dataset
- full-current
- Source SHA-256
- 5cf380f0061817c0331a6b2d8cc7e0ee3a79bea469a1001dc5c10e56f35f5ab3
Source notes (4)
- Unreviewed is an editorial label, not an investigation status. API-sourced is not report-checked or human-reviewed. Explicit event totals are used without summing aircraft injury tables; onboard allocation is withheld. Unknown values remain unknown. The operation category is mapped from the NTSB-reported FAR part and has not been reviewed.
- Filled from the NTSB case API where the bulk record had no value: investigation status. Values present in the bulk record are kept.
- The date is the local date, which is the same as the UTC date the NTSB stores.
- API snapshot SHA-256: 6c01b20c532b07dba4e3886eb6745d83bbb0753009a9e45f1e0eb8c0d69231d2; retrieved 2026-09-16T05:35:20.598Z.