CEN15LA239 · Ayres Corporation S2R G6
A T Ag Services Ayres Corporation S2R G6 · Accident: nose over/nose down during landing
From Tivoli, TX to Tivoli, TX
Event
- NTSB case
- CEN15LA239
- Event typeAccident: someone killed or seriously injured, or the aircraft substantially damaged (NTSB definition). Incident: an occurrence that affected or could have affected safety, short of that. Glossary
- Accident
- InvestigationHow far the investigation had got when the record was published: preliminary, ongoing, final or completed. Unknown where the source does not say. Glossary
- Completed
- API-reported fatalities
- 0 · all aircraft and ground
- Ground fatalities
- 0
- OperationWhat kind of flying it was, grouped by the rules it flew under: airline (US Part 121), air taxi and commuter (Part 135), general aviation (Part 91 and similar), military or government. Glossary
- General aviation
- WeatherVisual meteorological conditions (VMC): good enough to fly by looking outside. Instrument conditions (IMC): cloud or low visibility, flying by instruments. Glossary
- Visual Meteorological Cond
Ayres Corporation S2R G6
- Aircraft type
- Ayres S2
- Category
- Airplane
- RegistrationThe aircraft's tail number, such as N12345 or G-ABCD. Registrations are reissued, so the same one years apart can be a different aircraft. Glossary
- N3300U
- Operator
- A T Ag Services
- Onboard fatalities
- Unknown
- Route
- From Tivoli, TXTo Tivoli, TX
- Aircraft age
- About 19 years (built 1996)
- Flight rulesThe regulations the flight operated under: in the US, Part 91 (general aviation), Part 121 (airlines), Part 135 (air taxi and commuter) and others; for flights abroad, the NTSB's coarser commercial or non-commercial code. Glossary
- Part 137: Agricultural
- Phase of flightThe stage of the flight when things started to go wrong: standing, taxi, takeoff, initial climb, en route, maneuvering, approach or landing. Glossary
- Landing
- Defining eventThe single coded event the NTSB judges best describes what happened (records from 2008 on). Older records name the first occurrence in the sequence instead. Glossary
- Nose over/nose down
- DamageDestroyed: beyond practical repair. Substantial: damage that affects the structure, performance or handling and normally needs major repair. Minor: less than that. Glossary
- Substantial
Cause areas
- Aircraft › Aircraft power plant
Approximate · Coordinates as recorded by the NTSB; no uncertainty radius is established.
NTSB narrative
The pilot reported that, during the accident flight, which was the twelfth aerial application flight of the day, the engine made an uncommanded power acceleration. The pilot retarded the throttle lever, but the engine did not respond. The pilot subsequently made a forced landing into a field, and the airplane nosed over and then came to rest inverted.
A postaccident examination of the airplane revealed no anomalies with the engine rigging. Examination of the fuel control unit revealed that the stub shaft spline was worn beyond the allowable limits. Such wear can allow the fuel control underspeed governor to be driven at a lower speed than the engine speed, which can increase fuel flow and engine speed and is consistent with the uncommanded power acceleration that occurred during the accident flight. A review of the airplane's maintenance records revealed that, 2 months before the accident flight, the fuel control unit was inspected for wear and damage in accordance with an airworthiness directive (AD). It is unlikely that the wear observed during the postaccident examination could have occurred between the time of the AD inspection and the accident. It is likely that the AD was either not accomplished as noted in the maintenance records or that maintenance personnel inadequately conducted the inspection.
Probable cause
The failure of the fuel control unit due to the worn stub shaft spline, which resulted in an engine overspeed. Contributing to the accident was maintenance personnel's inadequate inspection of the fuel control unit.
Verbatim NTSB analysis and probable cause from the NTSB dataset
Sources
NTSB record CEN15LA239
- Event ID
- 20150520X71702
- Case number
- CEN15LA239
- Dataset
- full-current
- Source SHA-256
- 5cf380f0061817c0331a6b2d8cc7e0ee3a79bea469a1001dc5c10e56f35f5ab3
Source notes (4)
- Unreviewed is an editorial label, not an investigation status. API-sourced is not report-checked or human-reviewed. Explicit event totals are used without summing aircraft injury tables; onboard allocation is withheld. Unknown values remain unknown. The operation category is mapped from the NTSB-reported FAR part and has not been reviewed.
- Filled from the NTSB case API where the bulk record had no value: investigation status. Values present in the bulk record are kept.
- The date is the local date, which is the same as the UTC date the NTSB stores.
- API snapshot SHA-256: e832321d65895b32214078b6b600bf3b3eed732841d152cd84ae1b035a6f3b3f; retrieved 2026-09-16T02:20:18.653Z.