ERA14LA361 · Hiller UH 12E
Summit Helicopters Hiller UH 12E · Accident: loss of engine power (partial) while maneuvering
From Wadesboro, NC to Wadesboro, NC
Event
- NTSB case
- ERA14LA361
- Event typeAccident: someone killed or seriously injured, or the aircraft substantially damaged (NTSB definition). Incident: an occurrence that affected or could have affected safety, short of that. Glossary
- Accident
- InvestigationHow far the investigation had got when the record was published: preliminary, ongoing, final or completed. Unknown where the source does not say. Glossary
- Completed
- API-reported fatalities
- 0 · all aircraft and ground
- Ground fatalities
- Unknown
- OperationWhat kind of flying it was, grouped by the rules it flew under: airline (US Part 121), air taxi and commuter (Part 135), general aviation (Part 91 and similar), military or government. Glossary
- General aviation
- WeatherVisual meteorological conditions (VMC): good enough to fly by looking outside. Instrument conditions (IMC): cloud or low visibility, flying by instruments. Glossary
- Visual Meteorological Cond
Hiller UH 12E
- Aircraft type
- Hiller UH-12
- Category
- Helicopter
- RegistrationThe aircraft's tail number, such as N12345 or G-ABCD. Registrations are reissued, so the same one years apart can be a different aircraft. Glossary
- N107HA
- Operator
- Summit Helicopters
- Onboard fatalities
- Unknown
- Route
- From Wadesboro, NCTo Wadesboro, NC
- Aircraft age
- About 40 years (built 1974)
- Flight rulesThe regulations the flight operated under: in the US, Part 91 (general aviation), Part 121 (airlines), Part 135 (air taxi and commuter) and others; for flights abroad, the NTSB's coarser commercial or non-commercial code. Glossary
- Part 137: Agricultural
- Phase of flightThe stage of the flight when things started to go wrong: standing, taxi, takeoff, initial climb, en route, maneuvering, approach or landing. Glossary
- Maneuvering · low-altitude flying
- Defining eventThe single coded event the NTSB judges best describes what happened (records from 2008 on). Older records name the first occurrence in the sequence instead. Glossary
- Loss of engine power (partial)
- DamageDestroyed: beyond practical repair. Substantial: damage that affects the structure, performance or handling and normally needs major repair. Minor: less than that. Glossary
- Substantial
Cause areas
- Aircraft › Aircraft power plant
- Not determined › Not determined
Approximate · Coordinates as recorded by the NTSB; no uncertainty radius is established.
NTSB narrative
The airline transport pilot was conducting an aerial application flight in the helicopter. About 75 ft above ground level, the pilot heard three engine compressor stalls, which were followed by a partial loss of engine power. During the ensuing forced landing to a nearby road, the helicopter rolled over into a drainage ditch and came to rest on its right side.
Examination of the engine revealed that the accessory gearbox No. 2 bearing had degraded and fractured. The bearing displayed evidence of heat damage associated with its degradation. The cage of the bearing revealed fatigue fractures with multiple origins, indicative of relatively high-stress concentrations to the bearing. The cage fractures were likely secondary failures following the initial degradation of the bearing. The bearing balls were black in appearance. In addition, they were undersized when compared to engineering drawing requirements and displayed signatures consistent with material loss, likely from wear.
Considering that the engine had accumulated only about 92 hours since the gearbox was installed following an overhaul, it was possible that the bearings experienced an abnormal load. The cause of the abnormal load could have been due to installation error, an alignment issue from a previous hard landing that was noted in the gearbox maintenance records, or from insufficient lubrication within the gearbox assembly. However, the investigation could not determine which of these factors, if any, caused the failure of the No. 2 bearing and resulted in the partial loss of engine power.
Probable cause
A partial loss of engine power due to the failure of the No. 2 engine accessory gearbox bearing for reasons that could not be determined based on the available information.
Verbatim NTSB analysis and probable cause from the NTSB dataset
Sources
NTSB record ERA14LA361
- Event ID
- 20140726X03559
- Case number
- ERA14LA361
- Dataset
- full-current
- Source SHA-256
- 5cf380f0061817c0331a6b2d8cc7e0ee3a79bea469a1001dc5c10e56f35f5ab3
Source notes (4)
- Unreviewed is an editorial label, not an investigation status. API-sourced is not report-checked or human-reviewed. Explicit event totals are used without summing aircraft injury tables; onboard allocation is withheld. Unknown values remain unknown. The operation category is mapped from the NTSB-reported FAR part and has not been reviewed.
- Filled from the NTSB case API where the bulk record had no value: investigation status. Values present in the bulk record are kept.
- The date is the local date, which is the same as the UTC date the NTSB stores.
- API snapshot SHA-256: f2db5a9e13ebd2d20fa8e1da6414a69697806463fd9ad2bda6cfaf73204a6126; retrieved 2026-09-16T00:59:37.757Z.