WPR13FA284 · Beech A45
Jet Test and Transport Beech A45 · Accident: loss of control in flight en route
From Chandler, AZ to North Las Vegas Airport (VGT)
Event
- NTSB case
- WPR13FA284
- Event typeAccident: someone killed or seriously injured, or the aircraft substantially damaged (NTSB definition). Incident: an occurrence that affected or could have affected safety, short of that. Glossary
- Accident
- InvestigationHow far the investigation had got when the record was published: preliminary, ongoing, final or completed. Unknown where the source does not say. Glossary
- Completed
- API-reported fatalities
- 2 · all aircraft and ground
- Ground fatalities
- Unknown
- OperationWhat kind of flying it was, grouped by the rules it flew under: airline (US Part 121), air taxi and commuter (Part 135), general aviation (Part 91 and similar), military or government. Glossary
- General aviation
- WeatherVisual meteorological conditions (VMC): good enough to fly by looking outside. Instrument conditions (IMC): cloud or low visibility, flying by instruments. Glossary
- Visual Meteorological Cond
Beech A45
- Aircraft type
- Beechcraft 45
- Category
- Airplane
- RegistrationThe aircraft's tail number, such as N12345 or G-ABCD. Registrations are reissued, so the same one years apart can be a different aircraft. Glossary
- N434M
- Operator
- Jet Test and Transport
- Onboard fatalities
- Unknown
- Route
- From Chandler, AZTo North Las Vegas Airport (VGT), North Las Vegas, NV
- Aircraft age
- Not recorded
- Flight rulesThe regulations the flight operated under: in the US, Part 91 (general aviation), Part 121 (airlines), Part 135 (air taxi and commuter) and others; for flights abroad, the NTSB's coarser commercial or non-commercial code. Glossary
- Part 91: General Aviation
- Phase of flightThe stage of the flight when things started to go wrong: standing, taxi, takeoff, initial climb, en route, maneuvering, approach or landing. Glossary
- En route · descent
- Defining eventThe single coded event the NTSB judges best describes what happened (records from 2008 on). Older records name the first occurrence in the sequence instead. Glossary
- Loss of control in flight
- DamageDestroyed: beyond practical repair. Substantial: damage that affects the structure, performance or handling and normally needs major repair. Minor: less than that. Glossary
- Substantial
Cause areas
- Aircraft › Aircraft oper/perf/capability
- Personnel issues › Task performance
Approximate · Coordinates as recorded by the NTSB; no uncertainty radius is established.
NTSB narrative
The pilot, who was also the mechanic for the airplane, had replaced all six cylinders on the engine during the airplane's annual inspection; he reported that, 3 days before the accident, the engine was operated and ran well. On the day of the accident, he was returning the airplane to its home base following a maintenance inspection on the wings. The pilot was near the end of the flight when he contacted approach control and requested priority handling because an engine chip light had illuminated. Shortly thereafter, the pilot stated that the engine had lost power on a cylinder, and he declared an emergency. When the airplane was at 9,500 ft mean sea level, the pilot said that he was going to attempt to land at a nearby airport (elevation 2,201 ft). Before switching to the airport's common traffic advisory frequency (CTAF), the pilot reported to the approach controller that the airplane was at 3,800 ft with the landing gear down and that the situation was under control. The pilot did not contact approach control again and did not broadcast over the CTAF. The airplane collided with terrain in a nose- low attitude about 1 mile west of the airport. Postaccident examination of the airframe revealed no evidence of mechanical anomalies that would have precluded normal operation.
Postaccident examination of the engine revealed that the No. 6 cylinder had separated, and no nuts were located on its through bolts. Magnified examinations of the bolt threads found the thread profiles intact and only locally distorted, consistent with the nuts not being present during the No. 6 cylinder separation, which appeared to be the result of the incorrect assembly of the cylinder at the last cylinder change. Fretting damage on the mounting pad was observed, which indicates looseness and movement between the cylinder and the case that resulted from inadequate preload in the fasteners either through insufficient initial torque or loss of torque during operation. Considering the short time since cylinder installation, it is likely that the cylinder fasteners, or at least some of them, were not correctly torqued at installation.
Probable cause
The pilot/mechanic's loss of control during an emergency descent following a loss of engine power while in cruise flight. Contributing to the accident was the pilot/mechanic's incorrect assembly of the No. 6 cylinder at the last cylinder change, which resulted in a separation of the cylinder and the loss of engine power.
Verbatim NTSB analysis and probable cause from the NTSB dataset
Sources
NTSB record WPR13FA284
- Event ID
- 20130624X93000
- Case number
- WPR13FA284
- Dataset
- full-current
- Source SHA-256
- 5cf380f0061817c0331a6b2d8cc7e0ee3a79bea469a1001dc5c10e56f35f5ab3
Source notes (4)
- Unreviewed is an editorial label, not an investigation status. API-sourced is not report-checked or human-reviewed. Explicit event totals are used without summing aircraft injury tables; onboard allocation is withheld. Unknown values remain unknown. The operation category is mapped from the NTSB-reported FAR part and has not been reviewed.
- Filled from the NTSB case API where the bulk record had no value: investigation status. Values present in the bulk record are kept.
- The date is the local date, which is the same as the UTC date the NTSB stores.
- API snapshot SHA-256: f2a796603d4f43714077c362cd9627cde389e4e60774edda0d416b7f22ada103; retrieved 2026-09-14T15:59:41.002Z.