ERA13LA025 · Piper PA-28-140
Ace Pilot Training Piper PA-28-140 · Accident: loss of engine power (partial) during initial climb
From Lehigh Valley International Airport (ABE) to Lehigh Valley International Airport (ABE)
Event
- NTSB case
- ERA13LA025
- Event typeAccident: someone killed or seriously injured, or the aircraft substantially damaged (NTSB definition). Incident: an occurrence that affected or could have affected safety, short of that. Glossary
- Accident
- InvestigationHow far the investigation had got when the record was published: preliminary, ongoing, final or completed. Unknown where the source does not say. Glossary
- Completed
- API-reported fatalities
- 0 · all aircraft and ground
- Ground fatalities
- Unknown
- OperationWhat kind of flying it was, grouped by the rules it flew under: airline (US Part 121), air taxi and commuter (Part 135), general aviation (Part 91 and similar), military or government. Glossary
- General aviation
- WeatherVisual meteorological conditions (VMC): good enough to fly by looking outside. Instrument conditions (IMC): cloud or low visibility, flying by instruments. Glossary
- Visual Meteorological Cond
Piper PA-28-140
- Aircraft type
- Piper PA-28
- Category
- Airplane
- RegistrationThe aircraft's tail number, such as N12345 or G-ABCD. Registrations are reissued, so the same one years apart can be a different aircraft. Glossary
- N15037
- Operator
- Ace Pilot Training
- Onboard fatalities
- Unknown
- Route
- From Lehigh Valley International Airport (ABE), Allentown, PATo Lehigh Valley International Airport (ABE), Allentown, PA
- Aircraft age
- Not recorded
- Flight rulesThe regulations the flight operated under: in the US, Part 91 (general aviation), Part 121 (airlines), Part 135 (air taxi and commuter) and others; for flights abroad, the NTSB's coarser commercial or non-commercial code. Glossary
- Part 91: General Aviation
- Phase of flightThe stage of the flight when things started to go wrong: standing, taxi, takeoff, initial climb, en route, maneuvering, approach or landing. Glossary
- Initial climb
- Defining eventThe single coded event the NTSB judges best describes what happened (records from 2008 on). Older records name the first occurrence in the sequence instead. Glossary
- Loss of engine power (partial)
- DamageDestroyed: beyond practical repair. Substantial: damage that affects the structure, performance or handling and normally needs major repair. Minor: less than that. Glossary
- Substantial
Cause areas
- Aircraft › Aircraft power plant
- Personnel issues › Task performance
Approximate · Coordinates from the NTSB case API, which marks them as estimated or does not say; no uncertainty radius is established.
NTSB narrative
During the initial climb, the engine lost partial power, and the flight instructor performed a forced landing into a cornfield. During a subsequent test-run of the engine, the engine would lose all power if only the right magneto was selected. Laboratory examination of the right magneto revealed that seven teeth from its drive gear were fractured and exhibited single-sided bending fatigue, consistent with applied force in one direction over a period of time. At the time of the accident, the engine had accumulated about 2,300 hours since overhaul, which had been completed about 7 years prior. The accident magnetos had not been replaced or serviced since they were installed during engine overhaul. The engine manufacturer recommended overhauling the engine every 2,000 hours or 12 years, which would have included replacing the magnetos with new or overhauled units. Additionally, a service bulletin issued by the magneto manufacturer recommended inspecting the magnetos every 500 hours; however, there was no evidence that an inspection was ever performed during the 2,300-hour life of the failed magneto.
Probable cause
The operator's failure to perform magneto inspections per the manufacturer's recommendations and failure to comply with the engine manufacturer's recommended time interval for engine overhaul, which resulted in defects in the magnetos going undetected and the failure of the right magneto during initial climb.
Verbatim NTSB analysis and probable cause from the NTSB dataset
Sources
NTSB record ERA13LA025
- Event ID
- 20121016X60053
- Case number
- ERA13LA025
- Dataset
- full-current
- Source SHA-256
- 5cf380f0061817c0331a6b2d8cc7e0ee3a79bea469a1001dc5c10e56f35f5ab3
Source notes (4)
- Unreviewed is an editorial label, not an investigation status. API-sourced is not report-checked or human-reviewed. Explicit event totals are used without summing aircraft injury tables; onboard allocation is withheld. Unknown values remain unknown. The operation category is mapped from the NTSB-reported FAR part and has not been reviewed.
- Filled from the NTSB case API where the bulk record had no value: investigation status, coordinates. Values present in the bulk record are kept.
- The date is the local date, which is the same as the UTC date the NTSB stores.
- API snapshot SHA-256: 9df452effff8ceb7b1e6313760100368ef8d87ca31c222c3fb7408d1b420e3c8; retrieved 2026-09-15T20:11:12.058Z.