ERA11LA197 · Burr Andrew E XIV ROTORWAY EXEC 162F
Burr Andrew E XIV ROTORWAY EXEC 162F · Accident: loss of engine power (total) en route
From St Clair County Airport (PLR) to Talladega Municipal Airport (ASN)
Event
- NTSB case
- ERA11LA197
- Event typeAccident: someone killed or seriously injured, or the aircraft substantially damaged (NTSB definition). Incident: an occurrence that affected or could have affected safety, short of that. Glossary
- Accident
- InvestigationHow far the investigation had got when the record was published: preliminary, ongoing, final or completed. Unknown where the source does not say. Glossary
- Completed
- API-reported fatalities
- 0 · all aircraft and ground
- Ground fatalities
- Unknown
- OperationWhat kind of flying it was, grouped by the rules it flew under: airline (US Part 121), air taxi and commuter (Part 135), general aviation (Part 91 and similar), military or government. Glossary
- General aviation
- WeatherVisual meteorological conditions (VMC): good enough to fly by looking outside. Instrument conditions (IMC): cloud or low visibility, flying by instruments. Glossary
- Not recorded
Burr Andrew E XIV ROTORWAY EXEC 162F
- Aircraft type
- Burr Andrew E Xiv ROTORWAY EXEC 162F
- Category
- Helicopter
- RegistrationThe aircraft's tail number, such as N12345 or G-ABCD. Registrations are reissued, so the same one years apart can be a different aircraft. Glossary
- N192AB
- Operator
- Mark Heet
- Onboard fatalities
- Unknown
- Route
- From St Clair County Airport (PLR), Pell City, ALTo Talladega Municipal Airport (ASN), Talladega, AL
- Aircraft age
- Not recorded
- Flight rulesThe regulations the flight operated under: in the US, Part 91 (general aviation), Part 121 (airlines), Part 135 (air taxi and commuter) and others; for flights abroad, the NTSB's coarser commercial or non-commercial code. Glossary
- Part 91: General Aviation
- Phase of flightThe stage of the flight when things started to go wrong: standing, taxi, takeoff, initial climb, en route, maneuvering, approach or landing. Glossary
- En route · cruise
- Defining eventThe single coded event the NTSB judges best describes what happened (records from 2008 on). Older records name the first occurrence in the sequence instead. Glossary
- Loss of engine power (total)
- DamageDestroyed: beyond practical repair. Substantial: damage that affects the structure, performance or handling and normally needs major repair. Minor: less than that. Glossary
- Substantial
Cause areas
- Not determined › Not determined
Approximate · Coordinates as recorded by the NTSB; no uncertainty radius is established.
NTSB narrative
The experimental helicopter was equipped with a modified kit engine. After completing 1.7 hours of instruction, the instructor and pilot landed uneventfully and fueled the helicopter. Shortly after departure for a nearby airport, about 600 feet above ground level, the helicopter experienced a total loss of engine power. The instructor took control of the helicopter and performed an autorotation to a field; however, the helicopter rolled during touchdown and sustained substantial damage.
The experimental engine used the engine case and crankshaft of the kit engine, but an additional 40 horsepower was achieved with the use of modified cylinders, valves, and two digital engine control units (DECUs). If the DECUs sensed a fuel flow disruption, they would reduce engine power to idle. Examination of the wreckage revealed that there was adequate fuel on board. The fuel and fuel filter were absent of contamination. The engine was started and ran continuously for approximately 10 minutes.
According to the pilot, who was also the owner of the helicopter, the fuel line was routed next to a hot water line, and a radiator hose was used to separate the two lines. During the accident flight, just prior to the loss of engine power, the pilot noted that the engine was hot, the water temperature was 210 degrees Fahrenheit (F), and the oil temperature was 165 degrees F. The pilot added that the water temperature should only usually be about 10 degrees F hotter than the oil temperature. He believed that heat from the water line caused a vapor lock in the fuel line. Subsequently, when the DECUs sensed a disruption of fuel flow, they reduced engine power to idle; however, that theory could not be verified during a postaccident wreckage examination or an engine test run. The ambient temperature at the time of the accident was 81 degrees F.
Probable cause
A total loss of engine power during cruise flight for undetermined reasons.
Verbatim NTSB analysis and probable cause from the NTSB dataset
Sources
NTSB record ERA11LA197
- Event ID
- 20110320X15018
- Case number
- ERA11LA197
- Dataset
- full-current
- Source SHA-256
- 5cf380f0061817c0331a6b2d8cc7e0ee3a79bea469a1001dc5c10e56f35f5ab3
Source notes (4)
- Unreviewed is an editorial label, not an investigation status. API-sourced is not report-checked or human-reviewed. Explicit event totals are used without summing aircraft injury tables; onboard allocation is withheld. Unknown values remain unknown. The operation category is mapped from the NTSB-reported FAR part and has not been reviewed.
- Filled from the NTSB case API where the bulk record had no value: investigation status. Values present in the bulk record are kept.
- The date is the local date, which is the same as the UTC date the NTSB stores.
- API snapshot SHA-256: 37d5575ac1c5d809b05d0905fb83ea775844e202f252363cfe0f567cd2b643b0; retrieved 2026-09-15T15:56:16.637Z.