FTW00LA042 · King LANCAIR 235/320 LANCAIR 23
King LANCAIR 235/320 LANCAIR 23 · Accident: propeller failure/malfunction en route
From Kerrville / Kerr County Airport at Louis Schreiner Field (ERV) to T49 · Big Spring, TX
Event
- NTSB case
- FTW00LA042
- Event typeAccident: someone killed or seriously injured, or the aircraft substantially damaged (NTSB definition). Incident: an occurrence that affected or could have affected safety, short of that. Glossary
- Accident
- InvestigationHow far the investigation had got when the record was published: preliminary, ongoing, final or completed. Unknown where the source does not say. Glossary
- Completed
- API-reported fatalities
- 0 · all aircraft and ground
- Ground fatalities
- 0
- OperationWhat kind of flying it was, grouped by the rules it flew under: airline (US Part 121), air taxi and commuter (Part 135), general aviation (Part 91 and similar), military or government. Glossary
- General aviation
- WeatherVisual meteorological conditions (VMC): good enough to fly by looking outside. Instrument conditions (IMC): cloud or low visibility, flying by instruments. Glossary
- Visual Meteorological Cond
King LANCAIR 235/320 LANCAIR 23
- Aircraft type
- King LANCAIR 235
- Category
- Airplane
- RegistrationThe aircraft's tail number, such as N12345 or G-ABCD. Registrations are reissued, so the same one years apart can be a different aircraft. Glossary
- N717SK
- Operator
- Unknown
- Onboard fatalities
- Unknown
- Route
- From Kerrville / Kerr County Airport at Louis Schreiner Field (ERV), Kerrville, TXTo T49 · Big Spring, TX
- Aircraft age
- Not recorded
- Flight rulesThe regulations the flight operated under: in the US, Part 91 (general aviation), Part 121 (airlines), Part 135 (air taxi and commuter) and others; for flights abroad, the NTSB's coarser commercial or non-commercial code. Glossary
- Part 91: General Aviation
- Phase of flightThe stage of the flight when things started to go wrong: standing, taxi, takeoff, initial climb, en route, maneuvering, approach or landing. Glossary
- En route · cruise
- First occurrenceThe single coded event the NTSB judges best describes what happened (records from 2008 on). Older records name the first occurrence in the sequence instead. Glossary
- Propeller failure/malfunction
- Also codedOther events the NTSB coded in the sequence, such as a wire strike after a loss of power. Flight Findings uses them for its kinds of event. Glossary
- Wire, transmission
- DamageDestroyed: beyond practical repair. Substantial: damage that affects the structure, performance or handling and normally needs major repair. Minor: less than that. Glossary
- Substantial
Cause areas
- Miscellaneous, bolt/nut/fastener/clamp/spring › Fatigue
- Other maintenance personnel › Maintenance, installation, improper
Approximate · Coordinates as recorded by the NTSB; no uncertainty radius is established.
NTSB narrative
During descent, the propeller separated from the experimental airplane. The pilot initiated a forced landing to a county road, and during the approach, the left main landing gear 'struck the bottom wire of a two wire service line,' which crossed over the road. The airplane 'stalled,' yawed 20 degrees to the left, and 'hit the middle of the road on all three [landing] gear.' It then headed off the left shoulder of the road where the right wing hit a road sign, shearing off the outboard 4 feet of the wing. The propeller system was not recovered. Examination of four of the six propeller attaching bolts revealed that they failed as a result of fatigue. The shank of one of the bolts, in the area located immediately adjacent to the fracture face had been subjected to 'extensive rubbing damage.' Two of the submitted bolt pieces contained washers. Examination showed that both washers were permanently deformed into dish shapes and were galled by rubbing. Rubbing and galling damage was also found on contact surfaces of the self locking nuts on all four bolts. The 3-bladed wooden experimental propeller had 47.4 hours since installation. The combination of low time since installation and rubbing damage on the bolts indicates the application of inadequate pre-stress (low torque) during propeller installation.
Probable cause
The fatigue fracture of the propeller attaching bolts, due to improper torque during the installation of the propeller by other maintenance personnel. A factor was the lack of suitable terrain for the forced landing.
Verbatim NTSB analysis and probable cause from the NTSB dataset
Sources
NTSB record FTW00LA042
- Event ID
- 20001212X20239
- Case number
- FTW00LA042
- Dataset
- historical-pre2008
- Source SHA-256
- 89e2df6d848e7ab3b42e7d7c7a03ff403303057a26ca04c95b3ea67201c3ce74
Source notes (4)
- Unreviewed is an editorial label, not an investigation status. API-sourced is not report-checked or human-reviewed. Explicit event totals are used without summing aircraft injury tables; onboard allocation is withheld. Unknown values remain unknown. The operation category is mapped from the NTSB-reported FAR part and has not been reviewed.
- Filled from the NTSB case API where the bulk record had no value: investigation status. Values present in the bulk record are kept.
- The date is the local date, which is the same as the UTC date the NTSB stores.
- API snapshot SHA-256: e89e247205cfa12b7324e8f5854242f4488cd8ab651907ac5bd3e03156b67992; retrieved 2026-09-22T13:33:29.216Z.