FTW97IA362 · Ayres S2R-G10
Ayres S2R-G10 · Incident: total loss of engine power (non-mechanical) during initial climb
From 37F to Haskell Municipal Airport (15F)
Event
- NTSB case
- FTW97IA362
- Event typeAccident: someone killed or seriously injured, or the aircraft substantially damaged (NTSB definition). Incident: an occurrence that affected or could have affected safety, short of that. Glossary
- Incident
- InvestigationHow far the investigation had got when the record was published: preliminary, ongoing, final or completed. Unknown where the source does not say. Glossary
- Completed
- API-reported fatalities
- 0 · all aircraft and ground
- Ground fatalities
- 0
- OperationWhat kind of flying it was, grouped by the rules it flew under: airline (US Part 121), air taxi and commuter (Part 135), general aviation (Part 91 and similar), military or government. Glossary
- General aviation
- WeatherVisual meteorological conditions (VMC): good enough to fly by looking outside. Instrument conditions (IMC): cloud or low visibility, flying by instruments. Glossary
- Visual Meteorological Cond
Ayres S2R-G10
- Aircraft type
- Ayres S2
- Category
- Airplane
- RegistrationThe aircraft's tail number, such as N12345 or G-ABCD. Registrations are reissued, so the same one years apart can be a different aircraft. Glossary
- N3298Y
- Operator
- Unknown
- Onboard fatalities
- Unknown
- Route
- From 37FTo Haskell Municipal Airport (15F), Haskell, TX
- Aircraft age
- Not recorded
- Flight rulesThe regulations the flight operated under: in the US, Part 91 (general aviation), Part 121 (airlines), Part 135 (air taxi and commuter) and others; for flights abroad, the NTSB's coarser commercial or non-commercial code. Glossary
- Part 91: General Aviation
- Phase of flightThe stage of the flight when things started to go wrong: standing, taxi, takeoff, initial climb, en route, maneuvering, approach or landing. Glossary
- Initial climb
- First occurrenceThe single coded event the NTSB judges best describes what happened (records from 2008 on). Older records name the first occurrence in the sequence instead. Glossary
- Total loss of engine power (non-mechanical)
- Also codedOther events the NTSB coded in the sequence, such as a wire strike after a loss of power. Flight Findings uses them for its kinds of event. Glossary
- Fuel starvation
- DamageDestroyed: beyond practical repair. Substantial: damage that affects the structure, performance or handling and normally needs major repair. Minor: less than that. Glossary
- Minor
Cause areas
- Fluid, fuel › Starvation
- Fuel system › Foreign material/substance
- Fuel system, line › Blocked(total)
Approximate · Coordinates as recorded by the NTSB; no uncertainty radius is established.
NTSB narrative
During the initial takeoff climb, the agricultural airplane's engine lost power, and the pilot executed a forced landing in a plowed field. The airplane nosed down in the soft ground. Examination of the airplane by the operator revealed that the right wing fuel tank was empty, and the left tank contained approximately 80 gallons of fuel. Both fuel lines leading from the left wing tank to the fuselage header tank were blocked by pellets of what appeared to be silicone rubber. Chemical analysis confirmed that the pellets were composed of silicone rubber. The 1995 model airplane had accumulated 612 hours total time. The operator expressed the opinion that the silicone rubber might have been applied to the gaskets of the wing fuel tank access panels during manufacture of the airplane; however, a representative of the manufacturer stated that the company did not use silicone rubber to seal fuel tanks. An inspection of the manufacturer's production line by FAA personnel revealed no evidence that silicone rubber was being used to seal fuel tanks. The source of the silicone rubber contamination could not be determined.
Probable cause
blockage of both fuel lines from the left wing tank to the header tank by silicone rubber contaminants (foreign material), which resulted in fuel starvation. A related factor was the lack of suitable terrain for the forced landing.
Verbatim NTSB analysis and probable cause from the NTSB dataset
Sources
NTSB record FTW97IA362
- Event ID
- 20001208X07903
- Case number
- FTW97IA362
- Dataset
- historical-pre2008
- Source SHA-256
- 89e2df6d848e7ab3b42e7d7c7a03ff403303057a26ca04c95b3ea67201c3ce74
Source notes (4)
- Unreviewed is an editorial label, not an investigation status. API-sourced is not report-checked or human-reviewed. Explicit event totals are used without summing aircraft injury tables; onboard allocation is withheld. Unknown values remain unknown. The operation category is mapped from the NTSB-reported FAR part and has not been reviewed.
- Filled from the NTSB case API where the bulk record had no value: investigation status. Values present in the bulk record are kept.
- The date is the local date, which is the same as the UTC date the NTSB stores.
- API snapshot SHA-256: 660d4fc9f6189601dcc99976521fdbd752c786c07015d58fdabc7b4a0b4f03ef; retrieved 2026-09-22T19:45:37.932Z.