CHI94LA332 · Cessna 170
Cessna 170 · Accident: partial loss of engine power (mechanical failure) en route
From Greene County/Lewis A. Jackson Regional Airport (I19) to Greater Kankakee Airport (IKK)
Event
- NTSB case
- CHI94LA332
- Event typeAccident: someone killed or seriously injured, or the aircraft substantially damaged (NTSB definition). Incident: an occurrence that affected or could have affected safety, short of that. Glossary
- Accident
- InvestigationHow far the investigation had got when the record was published: preliminary, ongoing, final or completed. Unknown where the source does not say. Glossary
- Completed
- API-reported fatalities
- 0 · all aircraft and ground
- Ground fatalities
- 0
- OperationWhat kind of flying it was, grouped by the rules it flew under: airline (US Part 121), air taxi and commuter (Part 135), general aviation (Part 91 and similar), military or government. Glossary
- General aviation
- WeatherVisual meteorological conditions (VMC): good enough to fly by looking outside. Instrument conditions (IMC): cloud or low visibility, flying by instruments. Glossary
- Visual Meteorological Cond
Cessna 170
- Aircraft type
- Cessna 170
- Category
- Airplane
- RegistrationThe aircraft's tail number, such as N12345 or G-ABCD. Registrations are reissued, so the same one years apart can be a different aircraft. Glossary
- N4216V
- Operator
- Todd W. Deckard · private individual
- Onboard fatalities
- Unknown
- Route
- From Greene County/Lewis A. Jackson Regional Airport (I19), GREEN COUNTY, OHTo Greater Kankakee Airport (IKK), Kankakee, IL
- Aircraft age
- Not recorded
- Flight rulesThe regulations the flight operated under: in the US, Part 91 (general aviation), Part 121 (airlines), Part 135 (air taxi and commuter) and others; for flights abroad, the NTSB's coarser commercial or non-commercial code. Glossary
- Part 91: General Aviation
- Phase of flightThe stage of the flight when things started to go wrong: standing, taxi, takeoff, initial climb, en route, maneuvering, approach or landing. Glossary
- En route · cruise
- First occurrenceThe single coded event the NTSB judges best describes what happened (records from 2008 on). Older records name the first occurrence in the sequence instead. Glossary
- Partial loss of engine power (mechanical failure)
- DamageDestroyed: beyond practical repair. Substantial: damage that affects the structure, performance or handling and normally needs major repair. Minor: less than that. Glossary
- Substantial
Cause areas
- Engine assembly, cylinder › Corroded
- Other maintenance personnel › Maintenance, rebuild/remanufacture, inadequate
Approximate · Coordinates as recorded by the NTSB; no uncertainty radius is established.
NTSB narrative
WHILE EN ROUTE, THE PILOT HEARD A REPETITIVE LOUD KNOCKING SOUND FROM THE ENGINE. THE EXHAUST GAS TEMPERATURE GAGE SHOWED A RAPID DROP, AND THE ENGINE BEGAN TO SURGE. UNABLE TO MAINTAIN ALTITUDE, THE PILOT ELECTED TO MAKE AN EMERGENCY LANDING. AN EXTREMELY LOUD BANG WAS THEN HEARD, AND THE UPPER PART OF THE COWLING BLEW OPEN AND BACK TOWARD THE WINDSHIELD. THE PILOT SWITCHED THE FUEL SELECTOR TO THE OFF POSITION, CLOSED THE THROTTLE, PULLED THE MIXTURE CONTROL TO IDLE CUT-OFF, AND MADE A FORCED LANDING ON A ROAD. DURING THE LANDING ROLL, THE RIGHT WING STRUCK A POLE WHICH WAS LOCATED ON THE SIDE OF THE ROAD. POSTACCIDENT EXAMINATION REVEALED THE #2 CYLINDER HAD FRACTURED. CORROSION WAS VISIBLE ON THE FRACTURE SURFACES. MAINTENANCE RECORDS SHOWED THAT THE CYLINDER WAS REPLACED WITH A RECONDITIONED CYLINDER AT THE LAST ANNUAL INSPECTION ON 5/1/94. THE AIRPLANE HAD LOGGED 65 HRS SINCE THE INSPECTION.
Probable cause
ENGINE FAILURE DUE TO AN INADEQUATELY RECONDITIONED CYLINDER.
Verbatim NTSB analysis and probable cause from the NTSB dataset
Sources
NTSB record CHI94LA332
- Event ID
- 20001206X02215
- Case number
- CHI94LA332
- Dataset
- historical-pre2008
- Source SHA-256
- 89e2df6d848e7ab3b42e7d7c7a03ff403303057a26ca04c95b3ea67201c3ce74
Source notes (4)
- Unreviewed is an editorial label, not an investigation status. API-sourced is not report-checked or human-reviewed. Explicit event totals are used without summing aircraft injury tables; onboard allocation is withheld. Unknown values remain unknown. The operation category is mapped from the NTSB-reported FAR part and has not been reviewed.
- Filled from the NTSB case API where the bulk record had no value: investigation status. Values present in the bulk record are kept.
- The date is the local date, which is the same as the UTC date the NTSB stores.
- API snapshot SHA-256: b460aa2d440872b7dae96964be85b11810b9f73d44b3953528b5b37f92e83e83; retrieved 2026-09-23T00:38:13.749Z.